|
 |
|
|
|
 |
Asbestos Mill Board |
 |
|
|
| |
Asbestos Mill Board is an excellent heat resistant material, does not suffer any apreciable loss of strength at service temperature upto approximately 500°C (932°F) and even higher temperature when properly supported. |
Physical Properties : 1m * 1m |
| Max. Temperature |
550°C |
| Density : |
1.0 to 1.3 gms/c.c. |
| Max. Loss on Ignition : |
15% |
| Moisture Loss @ 105°C |
3% |
| Tensile Strength not less than : |
- |
| In one direction : |
12 kg/cm |
| In another direction : |
6 kg/cm |
| Thermal Conductivity : |
1.445 mw/cm |
| Degree |
- |
| Asbestos Content in % by Wt. of pure Asbestos : |
75% |
| Tolerance : |
Lenght ± 10 mm
Breadth ± 10 mm
Thickness ± 10%
Weight ± 10% |
|
|
 |
Size & Specification : |
 |
| |
Thickness in mm |
Wt.per Sheet in kg(approx) |
No.of Sheets per Crate |
1.5 |
1.7 |
60 |
3.0 |
3.3 |
30 |
4.0 |
4.4 |
25 |
5.0 |
5.5 |
20 |
6.0 |
6.6 |
15 |
10.0 |
11.0 |
10 |
12.5 |
14.0 |
8 |
20.0 |
23.0 |
5 |
25.0 |
28.0 |
4 |
|
|
|
|
Non Asbestos Fiber Glass |
|
|
|
|
|
|
|
| |
Glass Fiber Yarn, Tape, Rope Cloth, Sleeve :
These Products are made width Texturized Glass Fiber Yarn. It is a good substitute of Asbestos Products and can stand high temperature upto 450° to 550°, having very excellent insulation & heat resistance. These Products have high strength & are corrosion resistant.
|
Fibre Glass Brades :
Is the solid braided rope offered in square and round shapes.
Typically used to shield and protect hydraulic lines, steam, motor leads hoses, pipes & machinery from extreme radiant heat.
It can be reinforced with 'SS' wire inside the core or on the braiding.
Size :
6mm, 8mm, 10mm, 12.5mm, 16mm, 20mm, 25mm, 38mm, 51mm, 63mm dia & square section.
Packing :
2.5kg coils for sizes upto 12.5mm, 10kg coils for sizes above 38mm.
|
|
|
|
Fibre Glass Tapes :
Is the glass fibre tape.
GFT 1 is used for the thermal and corrosion protection of tubes, flanges, steam lines, valves, weld joints etc. Glass fibre tape can be reinforced with 'SS' wire.
Standard width : 25mm, 51mm, 75mm, 100mm.
Standard thickness :
1.5mm, 2mm, 3mm, 5mm.
Packing : 25 metre rolls.
|
|
Fibre Glass Cloth :
Is the glass fibre cloth.
GFT 2 is used for the thermal and corrosion protection of tubes, flanges, steam lines, valves, weld joints etc. Glass fibre cloth can be reinforced with 'SS' wire.
Standard width :
1meter.
Standard thickness :
1.5mm, 2mm, 3mm, 5mm.
Packing :
15 metre rolls for thickness upto 3mm. 10 metre roll for thickness above 3mm.
|
|
|
|
|
|
|
|
|
|
Non Asbestos Ceramic |
|
|
|
|
|
|
|
| |
Ceramics (NAM) Yarn, Tape, Rope, Cloth :
These Products offer very high temperature resistance i.e. upto 800° to 1200° used for heat insulation and very good replacement for Asbestos Products.
|
|
Square braid is dense, high performance ceramic fiber material fabricated from ceramic fiber yarn braided around a core of ceramic fiber rope to form a packing in square section. It is widely used for a broad variety of high temperature gasketing, packing and sealing application.
|
|
VEKRAM SQUARE ROPE |
Expansion joint packing for furnace, gaskets, door seal insulation, crucible lid seals, hot top seal, gasket for vacuum degassing of steel during pouring, tadpole gasket bilk material, replacement for asbestos.
|
|
|
| SIZE : Custom sizes upon requested. |
| Diameter : |
6X6-50X50MM ( 1/4” to 2”) |
| |
|
ROUND BRAID : |
Round braid is dense, high performance ceramic fiber material fabricated from ceramic fiber yarn braided around a core of ceramic fiber rope to form a packing in round section. It is widely used for a broad variety of high temperature gasketing, packing and sealing application.
|
TYPE : STB & HT
|
VEKRAM ROPE |
Expansion joint packing for furnace, gaskets, door seal insulation, crucible lid seals, hot top seal, gasket for vacuum degassing of steel during pouring, tadpole gasket bilk material, replacement for asbestos.
|
|
|
| SIZE : Customer sizes upon requested. |
| Diameter : |
6-50MM ( 1/4” to 2”) |
| |
TAPE |
Tape is a cost-effective industrial tape manufactured from ceramic fiber yarn, reinforced by a core of glass filament or stainless steel wire for high strength retention at elevated temperatures. Ideal for most high temperature application up to 1260 °C & 1430 °C. (2300°F & 2610°F).
|
|
TYPE : STB & HT |
|
LADDER TAPE |
|
|
ALU-TAPE |
APPLICATION : |
SELF- ADHESIVE |
|
Expansion joint / piping insulation / laminates / gaskets and seals / electrical insulation / welding and stress relieving curtains / lacing tape / filtration media / textile products for personnel protection / radiant heat shields / protection against high temperature / insulation of industrial chimney / gasket and wrapping material / Cable insulation / infrared radiating diffusers / boiler tadpole gaskets / fire protection / pipe hanger insulation.
|
|
|
TADPOLE |
SIZE : |
VEKRAM TAPE |
|
Thickness : 2-6 mm, Width 25–200mm, Length 30/50m |
|
| Ladder tape upon customer request. |
| Tadpole tape upon customer request. |
| Vekram tape surface coated by vermiculite coating. |
| Alu-tape surfaced coated by high quality aluminum foil. |
Vekram & Alu tape coated by 1 or 2 faces. |
CERAMIC CLOTH
|
Cloth is manufactured by ceramic fiber yarn, Reinforced by E-glass or Stainless steel wire, STB ideal for most high temperature application up to 1260 °C(2300°F) HT temperature application up to 1430°C(2610°F).
|
|
|
Thickness |
- |
- |
Width |
- |
Length |
Weave |
|
mm |
inch |
mm |
inch |
meter |
yard |
1.5 |
0.059 |
1000 |
39.37 |
30 |
32.8 |
Plain |
2 |
0.079 |
3 |
0.118 |
5 |
0.197 |
25 |
27.3 |
Multi-Layer |
6 |
0.236 |
20 |
21.9 |
ALU CLOTH |
9 |
0.354 |
10 |
10.9 |
|
|
|
|
|
|
